PLEASE NOTE, THIS IS A PRE-ADVERTISEMENT....THIS JEEP IS CURRENTLY IN OUR SHOP HERE AT DAS BEING COMPLETED....ESTIMATED DATE OF COMPLETION IS 8-01-18. THIS JEEP IS AVAILABLE NOW TO PURCHASE AND WILL BE COMPLETED AS ACCORDING TO THE BUILD SHEET BELOW.  THE PHOTOS OBVIOUSLY ONLY SHOW THE CURRENT STATUS BUT WE WILL UPDATE THEM DAILY AND WEEKLY.

 

      NEW DAS ENGINE

  • 030 BORE
  • NEW CRANKSHAFT
  • NEW PERFORMANCE CYLINDER HEAD - BRAND NEW CYLINDER HEAD, NOT REMAN
  • NEW VALVES AND SPRINGS
  • NEW CAMSHAFT
  • PERFORMANCE LIFTERS
  • NEW ROCKER ARMS
  • NEW HEAD BOLTS
  • NEW FULL GASKET SET
  • NEW HEAD GASKET SET
  • NEW REAR MAIN SEAL
  • NEW OIL PAN GASKET
  • NEW PISTONS
  • NEW PISTON RING SET
  • NEW MAIN BEARING SET
  • NEW ROD BEARING SET
  • NEW CAM BEARING SET
  • NEW THRUST WASHERS
  • NEW FREEZE PLUG SET
  • NEW HIGH VOLUME OIL PUMP
  • NEW OIL PICK UP TUBE
  • NEW TIMING CHAIN KIT

 

     SUSPENSION AND STEERING

  • 5.5" FULL LONG ARM RUBICON EXPRESS SUSPENSION  
  • RUBICON EXPRESS FRONT UPPER ADJUSTABLE CONTROL ARMS
  • RUBICON EXPRESS FRONT LOWER ADJUSTABLE CONTROL ARMS
  • RUBICON EXPRESS REAR LOWER ADJUSTABLE CONTROL ARMS
  • RUBICON EXPRESS REAR UPPER ADJUSTABLE CONTROL ARMS
  • 4 RUBICON EXPRESS UPGRADED COILS
  • FOX DUAL BODY SHOCKS
  • RUBICON EXPRESS EXTREME DUTY QUICK DISCONNECT FRONT SWAY BAR END LINKS
  • RUBICON EXPRESS REAR SWAY BAR LINKS
  • 4 NEW SWAY BAR BUSHINGS
  • 2 REAR SWAY BAR BUSHINGS
  • 2 RUBICON EXPRESS FRONT BUMP STOPS
  • 2 RUBICON EXPRESS BUMP STOPS
  • RUBICON EXPRESS HEAVY DUTY TIE ROD BAR
  • RUBICON EXPRESS EXTREME DUTY ADJUSTABLE FRONT TRACK BAR
  • RUBICON EXPRESS EXTREME DUTY ADJUSTABLE REAR TRACK BAR
  • MOOG DRAG SLEEVE
  • FOX  STEERING STABILIZER
  • RUBICON EXPRESS SKID PLATE PACKAGE
  • 1 TON JCR STEERING OVER THE KNUCKLE
  • 1 TON TIE ROD ENDS (4 TOTAL) 

 

   EXHAUST SYSTEM

  • NEW BANKS RAM AIR SYSTEM 
  • NEW BANKS COLD AIR INTAKE 
  • NEW BANKS HEADER 
  • NEW BANKS PERFORMANCE MUFFLER
  • NEW CATALYTIC CONVERTER 
  • NEW OVER THE AXLE TAIL PIPE 
  • NEW EXHAUST TIP 
  • ALL CONNECTIONS WELDED AND FLANGES CONNECTED WITH GRADE 10 BOLTS 

 

   BRAKE  SYSTEM

  • NEW PERFORMANCE FRONT ROTORS
  • NEW PERFORMANCE REAR ROTORS
  • NEW FRONT CALIPER 
  • NEW REAR CALIPERS
  • NEW FRONT AND REAR PADS 
  • NEW STAINLESS STEEL BRAKE LINES 
  • COMPLETE FLUSH AND REFILL WITH NEW FLUID 

 

   DRIVELINE SYSTEM

  • UPGRADED REAR DRIVESHAFT 
  • UPGRADED CLUTCH 
  • RESURFACED FLYWHEEL 
  • FRONT DIFF SERVICE - DRAIN, FLUSH, CLEANED, INSPECTED, REFILL WITH SYNTHETIC FLUID, SEALED
  • REAR DIFF SERVICE - DRAIN, FLUSH, CLEANED, INSPECTED, REFILL WITH SYNTHETIC FLUID, SEALED
  • TRANSMISSION SERVICE - DRAIN, FLUSH, CLEANED, INSPECTED, FILTER, GASKET,  REFILL WITH SYNTHETIC FLUID
  • TRANSFER CASE  SERVICE - DRAIN, FLUSH, CLEANED, INSPECTED, FILTER, GASKET,  REFILL WITH SYNTHETIC FLUID

 

     INTERIOR

  • DAS CUSTOM BLACK /RED LEATHER SEATS
  • FULL BEDRUG INTERIOR CARPET  
  • BLACK ALUMINUM GRAB HANDLES
  • SONY FRONT AND REAR SPEAKER UPGRADE
  • DEI ALARM AND REMOTE START

 

    EXTERIOR

  • 35" NITTO TRAIL TIRES  
  • DAS EXCLUSIVE 17" WHEELS
  • ARB FRONT BUMPER
  • WARN SYNTHETIC WINCH
  • REAR BUMPER WITH TIRE CARRIER
  • TRUCK LITE LED HEADLIGHTS
  • OTHER LED LIGHTING
  • RED ARB FRONT AND REAR DIFF COVERS
  • RED HI LIFT JACK
  • RED FUEL TANKS
  • BLACK ALUMINUM HOOD LATCHES

 

KEVLAR EXTERIOR

We stripped the body of this Rubicon and applied a two tone graphite gray and black finish. This Kevlar will hold up in the toughest environments and will require no attention other than a rinse off.  This Kevlar process was about a 8 day procedure to strip the entire body, prep and spray. This Kevlar is sprayed with a commercial application system much like Line-x using industrial grade equipment. We also applied 3 coats for a very thick yet even finish to make this exterior as close to indestructible as possible. 

  • GRAY KEVLAR HOOD
  • GRAY KEVLAR FENDERS
  • GRAY KEVLAR DOORS
  • GRAY KEVLAR REAR QUARTERS
  • BLACK KEVLAR FENDER FLARES
  • BLACK KEVLAR HARD TOP

 

THERE WILL BE MANY MORE SERVICES AND PARTS ADDED TO THIS TJ BUILD. WE WILL BE UPDATING THE BUILD SHEET AS WE GO!!! MANY OF OUR JEEPS DO NOT MAKE THEIR WAY TO THE MARKET AS THEY OFTEN GET SOLD DURNING THIS BUILDING PROCESS, PLEASE CONTACT US FOR MORE INFO!!!! BUILD IS SUBJECT TO CHANGE. 202-491-9929

UPDATED PICS AND VIDEO FROM 7-9-18


 

THESE PHOTOS BELOW SHOW WEEK 1 - 19 OF THE BUILD 


WEEK 20-22 OF THE BUILD, CUSTOM DAS HEATED LEATHER SEATS AND FINAL TOUCHES TO INTAKE SYSTEM AND RAM AIR